Product ID:617-80A MIRA-PLATE EPOXY THINNER
MSDS Date:06/11/1993
FSC:8010
NIIN:00F045066
MSDS Number: BYLBC

O'BRIEN CORPORATION

450 E GRAND AVENUE
SOUTH SAN FRANCISCO, CA 94080-6207
US

Emergency Phone: 415-761-2300/800-338-8084

Info Phone: 800-338-8084/415-761-2300

Cage: 85207

O'BRIEN CORPORATION, FULLER O'BRIEN PAINTS

SOUTH SAN FRANCISCO, CA 94080-6207 US

Cage: 85207

ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 10%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: <5%

OSHA PEL 50 PPM (SKIN)

ACGIH TLV: 25 PPM (SKIN)

837.23 GM/L

RTECS: 9999999VO

TOLUENE (IARC CARC- GROUP 3) *95-3*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 65%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 15%

OSHA PEL 410 MG/CUM

ACGIH TLV: 205 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 5%

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:ORAL LD50(RAT): 5840 MG/KG ISOPROPANOL
Routes of Entry: Inhalation:NO Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TOLUENE-INGESTION: ASPIRATION OF
MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL. TOLUENE IS A BLOOD TOXIN. PROLONGED/REPEATED OVEREXPOSURE TO
SOLVENTS MAY CAUSE PERMANENT BRAIN & CNS DAMAGE. INTENTIONAL
MISUSE BY DELIBERATELY CONCENTRATING & INHALING CONTENTS MAY BE
HARMFUL/FATAL. (SEE SUPP)
Explanation of Carcinogenicity:NONE

First Aid:INGESTION: DRINK 1-2 GLASSES OF WATER TO DILUTE. KEEP WARM,
QUIET. A DECISION TO INDUCE VOMITING MUST BE BASED ON ADVICE OF A
PHYSICIAN/POISON CONTROL CENTER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONS CIOUS PERSON. INHALATION: REMOVE TO FRESH AIR. RESTORE
BREATHING. EYES: IMMEDIATELY FLUSH W/COOL WATER FOR 15 MINS. SKIN:
WIPE OFF W/RAG & WASH THOROUGHLY W/SOAP & WATER. (SEE SUPP)

Flash Point:35F
Lower Limits:1
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT W/SCBA. WATER
MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO
HOT SURFACES REQUIRES SPECIAL PRECAUTIONS.

Spill Release Procedures:REMOVE IGNITION SOURCES. SOAK UP & REMOVE
W/INERT ABSORBENT MATERIAL W/NON-SPARKING TOOLS. PROVIDE ADEQUATE
VENTILATION. USE APPROVED VAPOR RESPIRATOR.

Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS &
AWAY FROM HIGH TEMP & IGNITION SOURCES. KEEP CONTAINER TIGHTLY
SEALED WHEN NOT IN USE.
Other Precautions:AVOID PROLONGED CONTACT W/SKIN. DON'T INGEST. KEEP
OUT OF REACH OF CHILDREN.

Respiratory Protection:USE A NIOSH/MSHA APPROVED PROPERLY FITTED
MECHANICAL RESPIRATOR TO AVOID BREATHING VAPOR/SPRAY MIST DURING
MIXING, SPRAYING, APPLICATION/CURING. USE A NIOSH/MSHA APPROVED
PROPERLY FITTED POSITIVE AIR SUPPLIED RESPIRATOR IN CONFINED
AREAS.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
AIR CONTAMINATION BELOW APPLICABLE EXPOSURE LEVEL/TLV LIMITS.
Protective Gloves:SYNTHETHIC RUBBER
Eye Protection:GOGGLES/SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:PROTECTIVE OVERALLS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DISCARD CONTAMINATED SHOES.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: CHRONIC EXPOSURE TO SOLVENTS MAY CAUSE DAMAGE TO
KIDNEYS, LIVER, LUNGS, BLOOD CELLS, BLOOD PRODUCING ORGANS
(MARROW), BLOOD STORING ORGAN (SPLEEN) & PERIPHERAL NERVOUS SYSTEM.
F IRST AID CONT'D: OBTAIN MEDICAL ATTENTION IN ALL CASES.

Boiling Pt:B.P. Text:176-231.8F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, BASES
Stability Condition to Avoid:HEAT, SPARKS, FLAME, ELECTRICAL EQUIPMENT,
HOT SURFACES.
Hazardous Decomposition Products:FUMES MAY CONTAIN CO, CO2, NITROGEN
DIOXIDE.

Waste Disposal Methods:DISPOSE IN SEALED METAL CONTAINER AWAY FROM HEAT
& FLAME IAW/FEDERAL, STATE & LOCAL REGULATIONS. DON'T INCINERATE
CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.